Browsed by
Month: January 2018

More Repairs on Willow

More Repairs on Willow

Owning a boat comes with a lot of responsibilities. The biggest one besides not hitting anything is maintenance and repairs. Some say it is a hole in the water which you dump money into. I agree and disagree with that statement. If it is your home than it is no different then home improvement projects or home repairs.

We had a good amount of time to do some maintenance with the mast out for almost a month. With all the rigging removed and out of the way, we took the opportunity to re bed the chain plates and jib car tracks. The chain plates were straightforward. Unbolt, pull them through the deck, apply some 4200, insert and re bolt. The jib car tracks were a different story. We had to pull back the vinyl interior to get to the nuts. Oh yeah, the liner has the original zippers which no longer work and had to be pried open. The hood for the oven also had to be taken off. And after all of that I had to squeeze into small opening and contort my arm to get the aft couple of bolts out. Once that was done, we cleaned the rails, installed butyl tape around the bolts and reversed the process. We now have safety pins instead of zippers, but hey, that is another project for another day.

During last winter we noticed a lot of water running into the head. We re caulked the teak accent piece above the head to no avail. It was time to pull the portlight out and re bed it. This was a lot simpler than I thought it would be. While taking it apart I notice that the frame was not tight and there was clear silicone. After looking carefully, I noticed that a temporary fix had been attempted but the inside ring was put on backwards, so it never got tight. Some more 4200 and the indoor waterfall was fixed.

The deck where the bow pulpit attaches was a concern during the survey. Somewhere along the line Willow had hit a piling with the pulpit and had some minor damage to the deck. This caused a bit of moisture to get into the core. Luckily there was no delamination. After contorting arms once again, we had it off and back on, leaving a day in between for the core to dry. Some of the bolts were bent so replacements were needed. There had to have been a lot of force to do that.

We had a couple of issues when it came to access in the interior of the boat. The mast step was inaccessible, hence the reason it was missed on the survey. We decided to leave access panels in these areas to make sure it could be monitored from here on out. Since the holly floor covered the port side access panel, we installed a hinge to make sure we could get to it and to create more storage under the floor. We also had an issue with a squeaky, bending floor in the companionway. I decided the best thing to do was to cut a hole and inspect because again, there was no access. After looking at the problem, the wood holding the floor was no longer attached to the stringer. A couple of screws fixed that right up. Now what to do with the panel I cut out. I went to the store and bought some two by two cedar and built a frame. Fixed!

Finally, the goofy table. Our main table has leaves on it which were falling off. But the only way to remove the table for fixing was to pull out the mast. Aha! While we had the mast out, we could fix it. I looked towards the previous owner of Willow for help with this. He is very knowledgeable of wood and has a nice woodworking area in his garage. After a week of gluing and cutting to make the table removeable with the mast installed, we got our table back. The whole time we were in the San Juan Islands we did not have a table. Glad to have our workspace back!

Sail On!

What is Life at Six Knots?

What is Life at Six Knots?

We thought long and hard before we picked the name for our blog. We wanted to convey something more than just sailing and living on a boat. Life at Six Knots is about a lifestyle, about choosing to follow our hearts and not what society or our families and friends think we should be doing. It’s about living our best life on our terms and focusing on the things we find important.

It’s about having adventures. Sailing. Hiking. Cooking. Exploring. Trying new things. Meeting new people. To sum it up: its about living life, not just admiring it from afar.

Check out the video below to see what Life at Six Knots really means to us.